Navy releases documents from Cold War loss of submarine USS Thresher

The Navy has begun releasing documents from the investigation into the 1963 sinking of the USS Thresher, the deadliest submarine disaster in U.S. history.

The first of the documents released were 300 pages from the official inquiry, and reveal that the sub was in ‘dangerous condition’ if it flooded with salt water in deep depths prior to the disaster on April 10, 1963.

The loss of the nuclear-powered submarine and all 129 men aboard during a test dive in the Atlantic Ocean delivered a blow to national pride during the Cold War and became the impetus for safety improvements.

‘The loss of Thresher was a defining event for the submarine service,’ said Rear Adm. William Houston, director of the undersea warfare division in the office of the chief of naval operations at the Pentagon.

 The Navy released documents on Wednesday detailing the sinking of the USS Thresher on April 10, 1963

The Thresher story was already well known. It had undergone sea trials and was back in the ocean for deep-dive testing about 220 miles off Massachusetts’ Cape Cod.

The first sign of trouble was a garbled message about a ‘minor difficulty’ after the 279-foot (85-meter) submarine descended to more than 800 feet.

The crew indicated it was attempting to empty ballast tanks in an effort to surface. Sailors on an accompanying rescue ship heard something about the ‘test depth.’ 

Then the sailors listened as the sub disintegrated under the crushing pressure of the sea.

'The loss of Thresher was a defining event for the submarine service,' said Rear Adm. William Houston, director of the undersea warfare division in the office of the chief of naval operations at the Pentagon

‘The loss of Thresher was a defining event for the submarine service,’ said Rear Adm. William Houston, director of the undersea warfare division in the office of the chief of naval operations at the Pentagon

The Navy inquiry found weaknesses in the design and construction of the first-in-class nuclear-powered submarine, which had been built at Portsmouth Naval Shipyard in Kittery, Maine, and based in Groton, Connecticut.

The documents released Wednesday included the timeline of the sinking, evidence lists, reports, testimony and correspondence. But there were some redactions. 

Even more than 50 years later, technical details including the test depth were redacted.

In the documents, the Navy said it believes an interior pipe burst and caused electrical problems that caused an emergency shutdown of the nuclear reactor.

The documents noted that the commanding officer’s evaluation of the first year of operations – before additional work was conducted at Portsmouth Naval Shipyard — included praise for the submarine. 

But he also said the submarine was overly complex in many areas and he noted a vulnerability of the auxiliary salt water system.

‘He stated, ‘In my opinion, the most dangerous condition that exists in Thresher is the danger of salt water flooding while at or near test depth,´’ the report said.

The brazed joints in pipes were a special concern, and many electrical panels were not adequately protected from sea water in the event of a leak, the report said.

The Navy inquiry found weaknesses in the design and construction of the first-in-class nuclear-powered submarine, which had been built at Portsmouth Naval Shipyard in Kittery, Maine, and based in Groton, Connecticut

 The Navy inquiry found weaknesses in the design and construction of the first-in-class nuclear-powered submarine, which had been built at Portsmouth Naval Shipyard in Kittery, Maine, and based in Groton, Connecticut

Even more than 50 years later, technical details including the test depth were redacted in the documents

Even more than 50 years later, technical details including the test depth were redacted in the documents

Resting on the ocean floor at a depth of 8,500 feet, the Thresher looks as though it went through a ‘shredding machine’ and is spread out over a mile, University of Rhode Island oceanographer Robert Ballard told The Associated Press in 2013. Ballard used his 1985 discovery of the RMS Titanic as a Cold War cover for surveying the Thresher.

Not everyone was satisfied with the Navy’s conclusions.

Retired Capt. James Bryant, commander of a Thresher-class submarine, requested the documents under the federal Freedom of Information Act and ultimately went to court to demand the documents´ release. He thinks there´s more to be learned from the documents, most of them classified.

Michael Shafer, whose father and uncle both died on the Thresher, said some of the families need to review the documents to see for themselves and fully understand what happened. His suspicion is that the Navy was pushing the limits and placing personnel at risk during the Cold War.

Emblem adopted in 1960 for the USS Thresher

Emblem adopted in 1960 for the USS Thresher

‘I want to know the truth, the whole truth. Not some smoke screen from the Navy,’ he said Wednesday from St. Petersburg, Florida.

A judge in February ordered the Navy to release the documents. The coronavirus pandemic delayed the review of the documents. Eventually, more than 1,000 pages of documents will be released.

If there was a silver lining, it was that the tragedy so shook the Navy that it accelerated safety improvements and created a program called SUBSAFE, an extensive series of design modifications, training and other improvements.

One submarine has sunk since then, the USS Scorpion in 1968, and it was not SUBSAFE-certified, the Navy said.

Nuclear-powered submarine the 'USS Thresher' steers through the sea, early 1960s, during a test

Nuclear-powered submarine the ‘USS Thresher’ steers through the sea, early 1960s, during a test

Some of the improvements included better welding techniques, and the main ballast tank blow system that helps a submarine reach the surface was made more effective.

Joy MacMillan, one of four siblings who lost their father, the submarine´s chief radioman, said it´s helpful to know the tragedy spurred safety improvements. But it´s still important for the families to have the documents, and some closure.

‘After being 57 years in the dark, it´s time for the families to know any and all information so that we can put it away. We can say, `Mistakes were made. Let´s move on,´’ MacMillan, of Brentwood, New Hampshire, said Wednesday.

The sinking was the first of a string of calamities in 1963.

The March on Washington was a turning point in the Civil Rights movement, but the Vietnam conflict grew, white supremacists bombed the 16th Street Baptist Church in Alabama and President John F. Kennedy was assassinated.

Add Comment